High Through-Put Dairies Can Save Time and Money with West-Agro's One-Step Acid Rinse and Sanitizers. 
 

A high quality West Agro acid sanitizer is an important component for today's high through-put dairies which require speed, efficiency and lower energy costs. 
 

Saving just 15 minutes per milking three times a day can provide up to 274 hours a year of additional milking time!
 
Dyne® is a non-foaming, EPA-registered iodine-based detergent germicide. Dyne's acidic formula allows you to sanitize and acid rinse your C.I.P. system in one step. 

Dyne is non-corrosive to stainless steel and won't burn like some chlorinated sanitizers. Its low-foaming detergents remove milk soils and milkstone and hard water buildup. Dyne helps to lower high SPC and PI counts caused by dirty equipment. 

Dyne is concentrated. Use 1 ounce per 10 gallons of warm water to sanitize pipelines in only two minutes. 

Use Dyne in conjunction with Dynemate® Powder or Dynemate® II Liquid C.I.P. cleaner as part of a two-step cleaning and sanitizing procedure. 

 
Mega-San™+ is a superior, low-foaming no-rinse acid sanitizer for C.I.P. systems. 

Mega-San+ effectively removes milkstone and hard water buildup. It helps to lower high SPC and PI counts caused by dirty equipment. And it reduces wash up time by eliminating the sanitizing step. 

Mega-San+ prevents iron staining and may be used on silicone. 

 
Approximate Cost of Acid Sanitizers Compared with Acid Rinse and Chlorinated Sanitizer.
 
ACID SANITIZER OPTIONS
_DYNE®______MEGASAN™+
ACID RINSE FOLLOWED BY CHLORINATED SANITIZER
Chemical Cost Per 50 Gallons of Water
$1.16
$1.08
$0.60
Electricity Costs For Extra Step In Cleaning Cycle:  
•Cost Of Heating Water
------
------
0.67
•Cost Of Running Vacuum Pump And Milk Pump
------
 
------
 
0.16
TOTAL COST
$1.16
$1.08
$1.43
•Time Saved Per Year
274 Hours 
274 Hours 
------
•Reduction In Fresh Water Usage Per Year
54,750 Gal. 
54,750 Gal. 
------
•Reduction In Waste Discharged Per Year
54,750 Gal. 
54,750 Gal. 
------
•Electricity Cost Savings
$908.85/Yr.
$908.85/Yr.
------
Assumes: 15 minutes per cycle; $0.10/kwh; 3 wash-ups per day
 
 
SAFETY TIP: Never mix chlorinated products, such as C.I.P. detergents and sanitizers, with acid cleaners. They will generate toxic chlorine gas. 
 
 
| | |
MORE INFORMATION/ 
WHERE TO BUY 
| |
E-MAIL
WEST AGRO
Information presented on this site is believed to be complete and accurate, and applies to West Agro's product offering in the United States of America. Outside of the U.S., please write or e-mail West Agro, or call 816-891-1600.
West Agro, Inc. , does not represent or warrant the accuracy of the information contained in this site and shall not be responsible for any special, incidental or consequential damages of any nature or kind whatsoever resulting from the use of or reliance on information presented on this site.
© 2004 West Agro, Inc.